Product ID:IMRON 5000 POLYURETHANE ENAMELS, 8989S
MSDS Date:01/01/1995
FSC:8010
NIIN:00N074012
MSDS Number: CCPZS

E I DUPONT DE NEMOURS & CO

1007 MARKET ST
WILMINGTON, DE 19899
US

Emergency Phone: 800-441-3637;800-424-9300(CHEMTREC)

Info Phone: 800-441-7515

Cage: 0ERJ7

E.I. DUPONT DE NEMOURS & CO

WILMINGTON, DE 19898 US

Telephone: 800-441-7515;800-441-9442

Cage: 18873

STANNANE, DIBUTYLBIS (LAUROYLOXY); (DIBUTYL TIN DILAURATE)

CAS: 77-58-7

RTECS: WH7000000

OSHA PEL 0.1 MG SN/M3 SKIN

ACGIH TLV: 0.1 MG SN/M3

7.0 @ 20C

CAS: 123-54-6

RTECS: SA1925000

OSHA PEL N/K

ACGIH TLV: N/K

NO EFT WAS SEEN AT 100 PPM. THE ODOR IS DISAGREEABLE

RTECS: 9999999ZZ

CAUSES EYE CORROSION AND

RTECS: 9999999ZZ

ABSORBED THROUGH THE SKIN IN HARMFUL AMOUNTS.

RTECS: 9999999ZZ

OVER THE SPILL & ALLOW TO SET 10 MIN, MINIMUM,

RTECS: 9999999ZZ

(TERGITOL TMN 10), 80% WATER/0-10% AMMONIA, 2-5%

RTECS: 9999999ZZ

PRESSURE. DO NOT SEAL THE CONTAINER. AFTER 48 HOURS,

RTECS: 9999999ZZ

REACTION TO ISOCYANATE SHOULD NOT USE OR BE

RTECS: 9999999ZZ

PROTECTION IN THE PAINTING AREA. FOLLOW THE

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:GENERAL EFTS: INGEST: GI DISTRESS
INHAL: MAY CAUSE NOSE & THROAT IRRIT. RPTD & PRLNG OVEREXP TO SOLVS
MAY LEAD TO PERM BRAIN & NERVOUS SYS DMG. EYE WATERING, HDCHS,
NAUS, DIZZ & LOSS OF COORDINATION A RE SIGNS THAT SOLV LEVELS ARE
TOO HIGH.(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SKIN & EYE CNTCT: MAY CAUSE
IRRIT/BURNING OF THE EYES. (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGESTION: CALL A PHYSICIAN IMMEDIATELY AND HAVE THE NAMES OF
INGREDIENTS AVAILABLE. INHALATION: IF AFFECTED BY INHALATION OF
VAPOR OR SPRAY MIST, REMOVE TO FRESH AIR. IF BREATHING DIFFICULTY
PERSISTS , OR OCCURS LATER, CONSULT A PHYSICIAN.EYE: IMMEDIATELY
FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES: CALL A MD.
SKIN: WASH WITH SOAP AND WATER. IF IRRITATION OCCURS, CONTACT A
PHYSICIAN.

Flash Point:-100F,-73C
Lower Limits:>0.9%
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER FROM FOG NOZZLES MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASH POINT, EMITS
FLAMM VAP WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMM AT TEMP BELOW THE FLASH POINT.

Spill Release Procedures:DO NOT BRTHE VAPS. DO NOT GET IN EYES/ON SKIN.
WEAR A POSITIVE PRESS SUPPLIED AIR VAP/PARTICULATE RESP (NIOSH
TC-19C), EYE PROT, GLOVES & PROT MATL. REMOVE SOURCES OF IGNITION.
ABSORB W/INERT MATL. VE NT AREA. POUR LIQ DECONTAMINATE SOLUTION
(ING 7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS & FLAME. CLOSE CNTNR AFTER EACH USE. GROUND
CONTAINERS WHEN POURING. DO NOT STORE ABOVE 120F.
Other Precautions:DO NOT SAND, FLAME CUT, BRAZE OR WELD DRY COATING
WITHOUT A NIOSH APPROVED RESPIRATOR OR APPROPRIATE VENTILATION.

Respiratory Protection:DO NOT BRTHE VAPS/MISTS. WEAR A POS PRESS
SUPPLIED AIR RESP (NIOSH (TC-19C) WHILE MIXING ACTIVATOR W/ANY
PAINT/CLEAR ENAMEL, DURING APPLICATN & UNTIL ALL VAP & SPRAY MISTS
ARE EXHST. INDIVIDUALS W/HIS TORY OF LUNG/BRTHG PROBS/PRIOR (ING
10)
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
KEEP CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR SMOKING.
Supplemental Safety and Health
EFTS OF OVEREXP: RPTD/PRLNGD LIQ CNTCT MAY CAUSE SKIN IRRIT
W/DISCOMFORT & DERM. SPECIFIC EFTS:2,4 PENTANEDIONE:CAN BE ABSORBED
THRU THE SKIN IN HARMFUL AMTS. RPTD EXPOS TO HIGH CONCENS HAS
CAUSED ADV ERSE HLTH EFTS IN LAB ANIMALS. THESE EFTS INVOLVED THE
CNS, IMMUNE SYS, & THE RED BLOOD CELL FORMING SYSTEM. (ING 4)

Boiling Pt:B.P. Text:>135F,>57C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.98
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:7-100

Stability Indicator/Materials to Avoid:YES
NONE REASONABLE FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2, SMOKE, OXIDES OF HEAVY
METALS IN INGREDIENTS SECTION.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.